Engines Mercedes MBE4000, service e-manual

Content General information Scope and use of this manual General description Aftertreatment system Electronic engine control system Environmental conditions Safety instructions and precautions Cpc vehicle interface harness Engine braking power Engine Engine trim covers and frames Cylinder head cover Cylinder head Cylinder block Front and rear engine lifting brackets Engine brake Front radial seal Rear radial seal Crankshaft wear sleeve Crankshaft assembly Front cover housing Crankshaft position sensor Crankshaft vibration damper and pulley Flywheel Ring gear Pilot bearing Engine barring tool Flywheel housing Piston, piston ring, and connecting rod Valves Rocker arm Camshaft and gear assembly Additional information Fuel system Electronic unit pump Fuel return and nozzle spill line Fuel overflow valve High pressure fuel line and transfer tube Fuel injector harness adaptor frame Fuel injector Protective sleeve Motor control module Fuel filter Fuel filter housing Fuel filter bracket Fuel hand primer pump Fuel pump Fuel pump drive Fuel doser valve (fdv) Doser block assembly Fuel doser valve coolant lines Additional information Lubrication system Lubrication system description Oil pan Piston oil spray nozzle Camshaft lubrication nozzle Oil pump and suction pipe Oil filter Oil cooler/filter housing Engine oil pressure/temperature sensor Oil fill-tube and oil dipstick Additional information Cooling system Cooling system Coolant pump Front idler and tensioner support Thermostat Engine coolant temperature sensor Cylinder head coolant vent line Additional information Fuel, lubricating oil, and coolant Fuel Lubricating oil Coolant Additional information Air intake system Air intake elbow and grid heater Intake throttle valve and adaptor Gas mixer housing Air intake manifold Electrostatic oil separator, crankcase separator, and Oil separator drain line Intake air temperature/pressure sensor Turbocharger Wastegate actuator Additional information Exhaust system Exhaust manifold assembly Brake gate Electronic proportional valve Additional information Exhaust gas recirculation components EGR gas inlet pipe EGR cooler gas outlet pipe EGR cooler and support bracket EGR cooler heat shield and mounting bracket EGR cooler coolant inlet tube EGR cooler coolant return tube EGR control valve Additional information Electrical equipment Drive belts Alternator/air conditioning compressor bracket Additional information Power take-off Front power take-off Rear engine power take-off Special equipment Air compressor flange Air compressor Additional information Operation and verification Preparation for a first time start Starting the engine Running the engine Stopping the engine Additional information Engine tune-up Checking the valve lash Adjusting the valve lash Additional information Preventive maintenance Scheduled intervals Engine storage Preparing engine for storage

Mercedes-Benz